Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 CRACKER BARREL OLD COUNTRY STORE #221 		License/Permit #
 BB077
Street Address
50 KEN HAYES DR
City/State
 BOURBONNAIS, IL 		ZIP Code
 60914
No. of Risk Factor/Intervention Violations 2
No. of Repeat Risk Factor/Intervention Violations 1
Date 12/06/2022
Time In 10:00 AM
Time Out 11:40 AM
Permit Holder
CBOCS WEST, INC 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized X X
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used X  

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean   X

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean   X
56 X Adequate ventilation & lighting; designated areas used X  

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: CRACKER BARREL OLD COUNTRY STORE #221 Establishment #: BB077
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: SUPER QUAT 0-OK Heat: 180 °F
CFPM Verification (name, ID#, expiration date):
MELINDA MATHYS
23379182
03/07/2028 		SUE REYNOLDS
20758048
06/28/2026 		KERRI ROLNIAK
20758049
06/28/2026 		REBECCA RALEIGH
22297874
06/24/2027

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
blueberries 40.00°F milk 40.00°F cole slaw 39.00°F
strawberries 40.00°F gravy 153.00°F pot pie 178.00°F
ranch 42.00°F shredded cheese 39.00°F sausage 158.00°F
cucumbers 37.00°F raw chicken 35.00°F /walk-in freezer 0.00°F
steak 40.00°F peach topping 39.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
16 P 4-501.114 (C): (C) A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at contact times specified under ¶4-703.11(C) shall meet the criteria specified under §7-204.11 Sanitizers, Criteria, shall be used in accordance with the EPA- registered label use instructions, and shall be used as follows: (C) A quaternary ammonium compound solution shall: (1) Have a minimum temperature of 24°C (75°F), (2) Have a concentration as specified under § 7-204.11 and as indicated by the manufacturer's use directions included in the labeling, and (3) Be used only in water with 500 MG/L hardness or less or in water having a hardness no greater than specified by the EPA-registered label use instructions.
Facility has switched over to the super quat sanitizer and still needs to come up with the ratio of water to sanitizer. Ensure that the solution is made up correctly so that the concentration is not too weak. - COS,Repeat (Correct By: Dec 6, 2022)
28 P 7-201.11: POISONOUS OR TOXIC MATERIALS shall be stored so they can not contaminate FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE­ SERVICE and SINGLE-USE ARTICLES by: (A) Separating the POISONOUS OR TOXIC MATERIALS by spacing or partitioning; and (B) Locating the POISONOUS OR TOXIC MATERIALS in an area that is not above FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE or SINGLE-USE ARTICLES. This paragraph does not apply to EQUIPMENT and UTENSIL cleaners and SANITIZERS that are stored in WAREWASHING areas for availability and convenience if the materials are stored to prevent contamination of FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES.
Observed a spray bottle with a little bit of chemical solution inside sitting on the shelf over the bags of potatoes and onions. Make sure all chemicals are stored away and below all food items. - COS (Correct By: Dec 6, 2022)
47 C 4-501.11 (B): (B) EQUIPMENT components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.
Observed several cooler/ warmers that have torn/ loose seal gaskets. Repair/replace and maintain by next routine inspection.
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
Observed the following areas in need of cleaning:
-Around the cookline still has a lot of grease and food debris
build up
-Inside of the weekend cooler that has meat loaf inside.
-The drawer cooler on the weekend use side has several bins
that have food debris left over.
- Shelves in the walk-in cooler.

Clean and maintain by next routine inspection Repeat
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
Observed the following floor areas in need of cleaning:
-Floor in the walk-in freezer
-Floor under the cook line equipment
Clean and maintain by next routine inspection Repeat
56 C 6-403.11: (A) Areas designated for EMPLOYEES to eat, drink, and use tobacco shall be located so that FOOD, EQUIPMENT, LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES are protected from contamination. (B) Lockers or other suitable facilities shall be located in a designated room or area where contamination of FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE and SINGLEUSE ARTICLES can not occur.
Observed some person items (purse, phone) left on the counters where food and single use napkins/utensils are stored. All personal items must be stored away and separate from food prep areas and equipment. - COS (Correct By: Dec 6, 2022)
Inspection Comments   REMEMBER THAT ANY BREADING THAT COMES IN CONTACT WITH ANY KIND OF RAW MEAT BUT BE TREATED AS A TEMPERATURE CONTROL FOOD PRODUCT AND BE REFRIGERATED.
HACCP Topic: PROPER HANDLING PROCEDURES FOR BREADED CHICKEN
 

Person In Charge

  TIM 		 

Date:

  12/06/2022
 

Inspector

  Angela Colon 		 

Follow-up:  Yes   No   Follow-up Date: